天堂中文在线免费观看-天堂中文在线观看-天堂中文在线www-天堂中文网-天堂中文www在线-天堂在线最新资源

Welcome to the official website of jiangsu libang electromechanical equipment co., LTD.

  • WeChat public number

  • Mobile web site
  • 中文

service hotline:

400-025-9918

NEWS

Industry dynamic

Location:Home > news > Industry dynamic - About the return oil of refrigeration compressor

About the return oil of refrigeration compressor
Release time:2018-6-8 11:35:09      Number of clicks:1892
I. what problems will occur if the return oil is not smooth:
The return oil of screw compressor is not smooth, which will cause a lot of lubricating oil to stay in evaporator pipeline. When the oil film increases to a certain extent, it will directly affect the system cooling. Machine oil shortage can't run on the other hand, need to constantly add lubricating oil, which can lead to the oil in the system, create a vicious cycle, increase the operation cost, lower reliability. In general, the circulation of a mixture of oil and gas under 1% of the refrigerant gas flow is allowed in the system.
Ii. Unobstructed oil recovery solution:
There are two ways to return the compressor oil. One is to return the oil from the oil separator and the other is to return the oil from the gas pipe.
Oil separator is installed on compressor exhaust pipe on the road, generally can isolate 50-95% of the oil, oil effect is good, quick speed, greatly reduce the amount of oil pipeline into the system, thus effectively prolong operation time without oil return.
Line special long cold storage refrigeration system, full liquid type ice-making system and low temperature freeze-drying equipment, boot after more than ten minutes or a few minutes without oil or oil return quantity very little case is not rare, bad design system will appear compressor oil pressure is too low and downtime. The installation of high efficiency oil separator in this refrigeration system can greatly extend the operation time of the compressor without oil return, so that the compressor can safely pass the crisis stage without oil return after starting up. Unseparated lubricating oil will enter the system and flow in the tube with the refrigerant, forming an oil circulation.
When the lubricating oil enters the evaporator, on the one hand, due to the low temperature and low solubility, part of the lubricating oil is separated from the refrigerant. On the other hand, the temperature is low and the viscosity is high, the separated lubricating oil is easy to attach to the inner wall of the pipe, and the flow is difficult. The lower the evaporation temperature, the more difficult it is to return the oil. This requires that the design and construction of the evaporative pipeline and the return pipeline must be conducive to the return of oil. The common practice is to adopt the design of the descending pipeline and ensure a high airflow speed. Special solvents are usually added to a particularly low temperature refrigeration system in addition to a high efficiency oil separator to prevent lubricating oil from blocking capillaries and expansion valves, and to help return oil.
In practical application, it is not uncommon to find oil recovery problems caused by the improper design of evaporator and return pipe. For R22 and R404A systems, it is very difficult to return the oil of the liquid-filled evaporator, and the design of the system return pipeline must be very careful. For such a system, the use of high efficiency oil can greatly reduce the amount of oil entering the system pipeline, effectively extending the time of no oil return to the return pipe after starting up.
When the compressor is higher than the evaporator position, the vertical oil return bend on the return pipe is required. Return oil bend as tight as possible to reduce oil storage. The distance between the oil return bend should be appropriate, the amount of oil return bend is large, some lubricating oil should be added. The return pipeline of the variable load system must also be careful. When the load is reduced, the return gas speed will be reduced, and the low speed is not conducive to the return oil. In order to ensure the oil recovery under low load, the vertical suction pipe can be used with double vertical pipe.
Moreover, frequent starting of the compressor is not conducive to oil recovery. Because the compressor stopped running for a very short period of time, there was no time to form a stable high speed air flow in the return pipe, so the lubricating oil could only be left in the pipeline. The compressor will run out of oil if the return oil is less than the running oil. The shorter the operation time, the longer the pipeline, the more complex the system, the more serious the problem of oil return. So in general, do not start the compressor frequently.
Lack of oil will cause serious lubrication deficiency, the root cause of the lack of oil is not the amount and speed of screw compressor running oil, but the system return oil is not good. Installation of oil separator can quickly return oil, to extend the compressor running time without oil return. The design of evaporator and return pipe must consider the return oil. Maintenance measures such as avoiding frequent start-up, regular defrosting, timely replacement of refrigerants, and timely replacement of wear and tear parts, such as bearings, are also helpful.
When designing the refrigeration system, it is essential to study the problem of oil recovery. Only by taking all aspects into consideration can a safe and reliable refrigeration system be ensured.
The last one:Key points of oil replacement in screw refrigeration compressor
Next:No more!

Return list

Recommended for you

  • Mobile web site

  • The official WeChat

版權(quán)所有: 江蘇利邦機(jī)電設(shè)備有限公司 Copyright ? 2018 蘇ICP備18027510號(hào)-1

主站蜘蛛池模板: www.久久精品视频| 极品少妇hdxx麻豆hdxx| 在线久综合色手机在线播放| 色欲香天天天综合网站| 中文字幕色婷婷在线精品中| 国产女女做受ⅹxx高潮| 中文字幕天天躁夜夜狠狠综合| 四虎影视久久久免费 | 色多多www视频在线观看免费| 欧美极品少妇×xxxbbb| 日本老师xxxxxxxxx79| 亚洲字幕av一区二区三区四区| 乱人伦中文字幕成人网站在线| 内射爽无广熟女亚洲| 亚洲色成人一区二区三区小说| 欧美一区二区在线观看视频| 国产成a人亚洲精v品无码| 亚洲精品在线免费观看视频| 97伦伦午夜电影理伦片| 国产aⅴ夜夜欢一区二区三区| 理论片人人51| 国产麻豆天美果冻无码视频| 人妻丰满av无码久久不卡| 欧美黑人又大又粗xxxxx| 精品人妻一区二区三区四区在线| 丁香四月婷婷| 欧美一区二区三区久久综| 亚洲精品9999久久久久无码| 九九草在线观看| 人妻少妇看a偷人无码精品| 四虎成人精品国产永久免费| 国产精品美女久久久浪潮av| 人妻中文字幕乱人伦在线 | a亚洲| 国产在线无码精品无码| 好爽…又高潮了免费毛片| 婷婷开心激情网| 国精无码欧精品亚洲一区| 免费黄色一级毛片| 一区二区三区视频| 乱亲女h秽乱长久久久|